Product ID:GLID-GUARD EPOXY CHROMATE METAL PRIMER 5251
MSDS Date:06/01/1992
FSC:NIIN:Submitter:F BT
Status Code:A
MSDS Number: CKYHG

GLIDDEN PAINT, ICI PAINTS

925 EUCLID AVE
CLEVELAND, OH 44115
US

Emergency Phone: 800-545-2643

Info Phone: 800-545-2643/216-344-8207

Cage: 01PD6

GLIDDEN PAINT, ICI PAINTS NORTH AMERICA

CLEVELAND, OH 44115 US

Telephone: 800-545-2643/216-344-8207

Cage: 01PD6

ORGANOPHILIC CLAY

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

FATTY ACIDS, C18-UNSATD., DIMERS, CMPDS. WITH

CAS: 68647-57-4

2-PROPANOL

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

BENZENE, METHYL-

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY BE
HARMFUL OR FATAL.
Explanation of Carcinogenicity:PRODUCTS IN THIS SERIES MAY CONTAIN
TOLUENE WHICH IS A POSSIBLE REPRODUCTIVE HAZARD BASED ON ANIMAL
DATA.
Effects of Overexposure:INHALATION: IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION,
FATIGUE, DROWSINESS, DIZZINESS, HEADACHE, LIGHTHEADEDNESS,
UNCOORDINATION. SKIN: IRRITATION OF SKIN. CAN CAUSE DERMATITIS,
DEFATTING, AND ALLERGIC RESPONSE. EYE: IRRITATION OF EYES. CAN
CAUSE BLURRED VISION, TEARING OF EYES, REDNESS OF EYES, SEVERE EYE
IRRITATION. INGESTION: MAY CAUSE LU NG INFLAMMATION AND DAMAGE DUE
TO ASPIRATION OF MATERIAL INTO LUNGS, MOUTH AND THROAT IRRITATION,
UNCOORDINATION, NAUSEA, VOMITING, APATHY, CENTRAL NERVOUS SYSTEM
DAMAGE.
Medical Cond Aggravated by Exposure:INGREDIENTS CONTAINED IN THESE
PRODUCTS HAVE BEEN REPORTED TO AGGRAVATE PREEXISTING EYE, SKIN,
RESPIRATORY, LUNG DISORDERS, CARDIAC ABNORMALITIES, KIDNEY, LIVER
AND NERVOUS SYSTEM DISORDERS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE AND SUPPORT
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN:
WASH OFF QUICKLY WITH PLENTY OF WATER, THEN SOAP AND WATER; REMOVE
CONTAMINATED C LOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSE.
EYE: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER, ESPECIALLY
UNDER LIDS, FOR AT LEAST 15 MINUTES. INGESTION: IF SWALLOWED,
OBTAIN MEDICAL TREATMEN T IMMEDIATELY! IN ALL CASES, SEEK
IMMEDIATE MEDICAL ATTENTION!

Flash Point:=4.4C, 40.F
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS. FIREFIGHTERS SHOULD USE FULL PROTECTIVE CLOTHING, EYE
PROTECTION, AND SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT OR FIRE. VAPORS MAY IGNITE EXPLOSIVELY AT
AMBIENT TEMPERATURES. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL
ALONG DISTANCES TO A SOURCE OF I GNITION AND FLASH BACK. MAY
DECOMPOSE UNDER FIRE CONDITIONS EMITTING IRRITANT AND/OR TOXIC
GASES.

Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS. ELIMINATE ALL SOURCES OF IGNITION.
VENTILATE AREA WITH EXPLOSION PROOF EQUIPMENT. SPILLS MAY BE
COLLECTED WITH NONCOMBUSTIBLE ABSORB ENT MATERIALS. USE
NON-SPARKING TOOLS. EVACUATE ALL UNNECESSARY PERSONNEL. TOXIC TO
FISH.

Handling and Storage Precautions:STORE BELOW 80 F. KEEP AWAY FROM
HEAT, SPARKS, AND OPEN FLAME.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT WITH SKIN
AND EYES, AND BREATHING OF VAPORS. WASH HANDS THOROUGHLY AFTER
HANDLING, ESPECIALLY B EFORE EATING OR SMOKING. KEEP CONTAINERS
TIGHTLY CLOSED AND UPRIGHT WHEN NOT IN USE.

Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED,
USE ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA
STANDARD 29 CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS. USE EXPLOSION-PROOF EQUIPMENT.
Protective Gloves:IMPERVIOUS GLOVES
Eye Protection:SAFETY GLASSES OR GOGGLES
Other Protective Equipment:EYE WASH, SAFETY SHOWER, IMPERVIOUS
CLOTHING, FACE SHIELDS, BOOTS
Supplemental Safety and Health
WT/GAL: 7.1

Boiling Pt:B.P. Text:179-231 F
Percent Volatiles by Volume:74.3

Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES, ORGANIC MATERIALS.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, FORMALDEHYDE, CHROMIUM OXIDE.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.

Toxicological Information:EXPOSURE TO MATERIALS IN THESE PRODUCTS HAVE
BEEN ASSOCIATED WITH POSSIBLE CARDIAC ABNORMALITIES, BLOOD
ABNORMALITIES, LIVER DAMAGE, KIDNEY DAMAGE. EXCESSIVE INHALATION
OF SOLVENT VAPORS UNDER UNCONT ROLLED CONDITIONS MAY LEAD TO
UNCONSCIOUSNESS, RESPIRATORY FAILURE, ASPHYXIATION, AND EVEN DEATH.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT PROPER SHIPPING NAME: PAINT, UN 1263

SARA Title III Information:SARA 313: TOLUENE
Federal Regulatory Information:CERCLA: TOLUENE